2006 s175 bogging down after working for 15 minutes

[mcanuel86]

hi i have a 06 s175 and it has been doing something odd for a few months now, mind you i use it maybe once a week but heres what happens. i will fire it up work it moving dirt with the bucket ect then after 10-20 minutes it will sputter/bog down/almost and stall if i push the levers to hard wether it be lifting lowering tiling the bucket or going back or forth. it does not matter the pisition of the throttle wether it be at max rpm or at idle as soon as i do anything move/lift lower or tilt it will bog down and go to stall. fuel filter has been changed no affect, cleaned out fuel lines no affect, it is always topped with hyd fluid. any ideas??? please help

 

[Bobcatdan]

Next time it does, have somebody watch the primer ball when it is bogging and see if it is sucking in. I had a rash a couple years a go of bad gas caps the wouldn't vent the tank. Pop the cap off and it would rev right back up.

 

[mcanuel86]

Next time it does, have somebody watch the primer ball when it is bogging and see if it is sucking in. I had a rash a couple years a go of bad gas caps the wouldn't vent the tank. Pop the cap off and it would rev right back up.

so ran it today again, was fine untill it warmed up, pulled the cap did not affect anything, thank you for the idea! had me excited! i want to say it is to due with the fuel system as it will rough idle and even at full throttle bog down from 2400rpm down to 1100 rpm when not under load at all.. my only other guesses would be a fuel pump or faulty or broken or clogged fuel pickup?

 

[mrdeere1959]

so ran it today again, was fine untill it warmed up, pulled the cap did not affect anything, thank you for the idea! had me excited! i want to say it is to due with the fuel system as it will rough idle and even at full throttle bog down from 2400rpm down to 1100 rpm when not under load at all.. my only other guesses would be a fuel pump or faulty or broken or clogged fuel pickup?

what does it do if you pump the primer bulb while its running poorly? if it picks up it not getting enough fuel

 

[mcanuel86]

what does it do if you pump the primer bulb while its running poorly? if it picks up it not getting enough fuel

pumping he bulb does not help either..